Yamaha XT1200Z Super Tenere Service Manual
When trouble-shoot a yamaha xt1200z super tenere, first begin with the fundamentals. These easy trials can work for any engine. All engines need three basic things to run fuel, spark and air. These easy things can cause your yamaha xt1200z super tenere to not start up or run sick.
DOWNLOAD THE XTZ1200 SERVICE MANUAL NOW CLICK HERE = Yamaha XT1200Z Super Tenere Manual
yamaha tenere xt 600
First start off with the fuel Withdraw the hose off the tank and make sure the fuel is flowing right. Some bikes will have to turn the fuel selector to prime, not on, or fuel will not run.Take a flashlight and look down into the tank, is the fuel varnished or is there dirt in the tank? Older yamaha yamaha xt1200z super teneres had a problem with tanks oxidizing inside and would plug the screen up inside the tank. Fuel delivery may still be a trouble but we will come back to that later.
Next Withdraw the spark plugs, you may need to Remove the tank to reach them. Inspect every spark plug as you take them out. All the spark plugs should look the same. If a plug looks white colored, that cylinder may be (lean) and not getting enough fuel.
2008 yamaha tenere for sale
If you have a plug that looks wet and black, that cylinder may getting too much fuel (rich) or not sparking good. Remove all the spark plugs and snap the plugs back into their conducting wires.yamaha tenere usa
Set the spark plugs on the engine so that they can ground themselves. Crank the bike over and watch the plugs for sparks, preferably somewhere dark. Make sure you look at all the plugs to make sure they are all sparking.yamaha tenere 1200 2010
If one spark looks down check the wire and plug, if old or worn replace them. If their is no spark the coil may be bad.If you have any test equipment such as an ohm meter, you can find out what the resistance reading should be for your bikes coils.yamaha tenere antalaktika xtz 1999
This way you will know for sure if the coils are o.k. If the ignition system looks fine move on to the carburetors. First, if the bike has not been maintained recently (a trouble in itself) make sure the carbs are synchronized. To do this you need a vacuum gauge made for this. Withdraw the small rubber plug located 'tween the carbs and the cylinder.yamaha tenere spec
Attach the gauge and take the readings from each cylinder. Replace the caps when not measuring or it won't run right. Correct the throttle screw or linkage for that carb until they all read close to one another. Refer back to inspecting the spark plugs. If one cylinder looked lean or rich check all hoses for cracks and air leaks. If the yamaha xt1200z super tenere has not been run in awhile the carbs may be (gummed up). Remove the float bowl off the bottom of the carb.yamaha tenere 660 for sale
Look in the bowl for dark varnish looking gas. If the fuel looks dark you will probably have to Withdraw the pilot and main jets and cautiously run a wire through the center hole to clean them out. Be careful to not bend the float as the height needs to be correct to run well As Well. Check that the small needle attached to the float between the pivot point, is moving up and down.yamaha tenere bike
If it doesn't move smoothly the carb will not fill up with gas or will run low as your driving down the road. Make sure you check the battery Also, if they become down the ignition system won't have enough power to keep the bike running swimmingly. If you still haven't found anything make sure you valve lash has been checked at the correct mileage intervals. If not this can make many problems with the way it runs.yamaha tenere 2010 usa
Also you can screw a compression gauge into the spark plug holes and check that they are within 5% 10% of for each one other. If one is way down you have a serious trouble either with the pistons, bore or valves. This should be a good start to finding a general problem with your yamaha yamaha xt1200z super tenere.DOWNLOAD THE XTZ1200 SERVICE MANUAL NOW CLICK HERE = Yamaha XT1200Z Super Tenere Manual
Share
No comments:
Post a Comment